Product ID:MIL-PRF-24635B,TYPEII, CLASS 1 ENAMEL, SILICONE ALKYD COPOLY
MSDS Date:11/29/2000
FSC:8010
NIIN:01-396-6805
Status Code:A
MSDS Number: CLPYZ

SHERWIN-WILLIAMS CO THE

101 PROSPECT AVE NW
CLEVELAND, OH 44115-1042
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902/216-566-2917

Preparer: ERNEST CARTER

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

MINERAL SPIRITS

CAS: 64742-88-7

LIGHT AROMATIC HYDROCARBONS

CAS: 64742-95-6

RTECS: WF3400000

1,3,5-TRIMETHYLBENZENE

CAS: 108-67-8

RTECS: OX6825000

1,2,4-TRIMETHYLBENZENE

CAS: 95-63-6

RTECS: DC3325000

2)

CAS: 136-52-7

1-METHOXY-2-PROPANOL ACETATE

CAS: 108-65-6

RTECS: AI8925000

CALCIUM CARBONATE

CAS: 471-34-1

RTECS: FF9335000

Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE
EXPOSURE, FOLLOW RECOMMENDATIONS FOR PROPER USE, VENTILATION, AND
PERSONAL PROTECTIVE EQUIPMENT.
Effects of Overexposure:IRRITATION OF EYES, SKIN AND RESPIRATORY
SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION, EXTREME OVEREXPOSURE
MAY RESULT IN UNCONSCIOUSNESS AND POSSIBLY DEATH. HEADACHE,
DIZZINESS, NAUSEA, AND LOSS OF CO ORDINATION ARE INDICATIONS OF
EXCESSIVE EXPOSURE TO VAPORS OR SPRAY MISTS. REDNESS AND ITCHING OR
BURNING SENSATION MAY INDICATE EYE OR EXCESSIVE SKIN EXPOSURE.

First Aid:IF INHALED: REMOVE FROM EXPOSURE. RESTORE BREATHING.KEEP WARM
AND QUIET.IF ON SKIN: WASH AFFECTED AREA THOROUGHLY WITH SOAP AND
WATER.REMOVE CONTAMINATED CLOTHING. IF IN EYES: FLUSH EYES WITH
LARGE AM OUNTS OF WATER FOR 15 MINUTES.GET MEDICAL ATTENTION. IF
SWALLOWED: GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:=37.8C, 100.F
Lower Limits:0.7%
Upper Limits:13.1%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. WATER SPRAY MAY
BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. WATER
MAY BE USED TO COOL CLOSED CO NTAINERS TO PREVENT PRESSURE BUILD UP
AND POSSIBLE AUTOIGNITION OR EXPLOSION WHEN EXPOSED TO EXTREME
HEAT.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO
HOT SURFACES REQUIRES SPECIA L PRECAUTIONS. DURING EMERGENCY
CONDITIONS OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION.VENTILATE AND
REMOVE WITH INERT ABSORBENT.

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN
USE.TRANSFER ONLY TO APPROVED CONTAINERS WITH COMPLETE AND
APROPRIATE LABELING. CONTENTS ARE COMBUSTIBLE. KEEP AWAY FROM HEAT
AND OPEN FLAMES. CONSULT NFPA CODE. USE APPROPRIATE BONDING AND
GROUNDING PROCEDURES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING AND
INHALING THE CONTENTS CAN BE HARMFUL OR FATAL.

Respiratory Protection:WEAR A PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA FOR PROTECTION AGAINST MATERIALS
IN SECTION II. WHEN SANDING OR ABRADING THE DRIED FILM, WEAR A
DUST/MIST RESPIRATOR APPROVED BY NIOSH/MSHA FOR DUST WHICH MAY BE
GENERATED FROM THIS PRODUCT, UNDERLYING PAINT, OR THE ABRASIVE.
Ventilation:USE ONLY WITH ADEQUATE VENTILATION.
Protective Gloves:WEAR GLOVES WHICH ARE RECOMMENDED BY GLOVE SUPPLIER
Eye Protection:WEAR SAFETY SPECTACLES WITH UNPERFORATED SIDESHIELDS.
Supplemental Safety and Health

Boiling Pt:=201.7C, 395.F
B.P. Text:284-395 F
Vapor Density:HEAVIER
Spec Gravity:1.10
VOC Pounds/Gallon:328
VOC Grams/Liter:2.74
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:39%

Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE,
AND LOCAL REGULATIONS REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:108-88-3, TOLUENE, 1% MAX; 1330-20-7,
XYLENE, 1% MAX; 95-63-6, 1,2,4-TRIMETHYLBENZENE, 8% MAX.; COBALT
COMPOUND, .2% BY WEIGHT.
State Regulatory Information:SARA 313 (40 CFR 372.65 C) SUPPLIER
NOTIFICATION